、 所有操作人员必须经过岗前培训合格，方能上岗。 All operators must be trained in the pre-job training to be on duty. 2、 电动葫芦应由专人操作。 Electric gourds should be operated by special people. 3、 起吊前应检查设备的安全性能，机械、钢丝绳、吊钩是否固定牢靠、转动部位灵活，电源、接地、按钮、行程开关是否良好且使用灵敏，限位器等应完好，左右跑道、滑轮、卷筒、制动、安装是否灵活、固定可靠、不得破损，电动机、减速器应无异常现象，楔块是否安装牢固可靠。 3, before lifting shall check the safety performance of equipment, machinery, steel wire rope, hook fixation, flexible rotating parts, power supply, grounding, buttons, stroke switches are in good condition and use of sensitive, limiter, etc should be in good condition, around the track, pulley, drum, brake, is flexible and reliable fixed installation, shall not be damaged, motor, reducer should be no abnormal phenomenon, whether wedge installation is firm and reliable. 4、 使用前若发现钢丝绳出现下列异常情况时，绝对不要操作。 Do not operate if the wire rope is found in the following abnormal condition. ① 弯曲、变形、磨损等。 Bend, distort, wear, etc. ② 钢丝绳断裂程度超过规定要求，磨损量大。 The degree of breakage of wire rope exceeds the requirement and the amount of wear is large. 5、 将上下限位的停止块调整后再起吊物体。 After adjusting the stop block of the upper and lower limit, lifting the object. 6、 在使用中起重物禁止超过500kg。每次起吊重物时，在吊离地面10cm应停车检查抽动情况，确认完好后方可进行工作。 In use, heavy objects are banned for over 500kg. Every time lifting heavy weight, at the hoisting to the ground 10cm should stop to check the pumping condition, confirm the good rear can carry on the work. 7、 调整电动葫芦制动下滑量时，应保证在额定载荷下。 When adjusting the sliding quantity of electric hoist, it should be guaranteed under the rated load. 8、 移动位置牵引不得过猛，速度禁止太快。吊物上升时，严防冲撞。 The movement of position is not too strong, the speed is forbidden too fast. When lifting up, keep the collision. 9、 起吊物件的下面不得有人。 No one is under the lifting object. 10、 起吊物上禁止乘人，绝对不要将电动葫芦作为电梯的起升机构用来载人。 No passenger is allowed on the lifting, and the electric gourd should not be used as the lifting mechanism for lifting people. 11、 提升时不得将挂勾提升超过电动葫芦以上。 The lifting shall not be raised above the electric gourd. 12、 在使用中，绝对禁止在不允许的环境下及超过额定负荷和每小时额定合闸次数（120次）的情况下使用。 In use, it is absolutely prohibited to be used in conditions that are not permitted and exceed the rated load and the rated number of times (120) per hour. 13、 单轨电动葫芦在轨道转弯处或接近轨道尽头时，必须减速运行。不允许同时按下两个使电动葫芦按相反方向运动的手电门按钮。 The monorail electric gourd must slow down when the orbit turns or near the end of the orbit. Not allowed to press two handphone buttons that cause the electric gourd to move in the opposite direction. 14、 物体要捆扎牢固，并在重心。 Objects should be tightly bound and centered. 15、 吊重行车时，重物离地不要太高，严禁重物从人头上超过。 When lifting heavy traffic, the weight should not be too high. 16、 工作间隙不得将重物悬在空中。起吊物体，吊钩在摇摆状态下不能起吊。 No weight is suspended in the air between work. Lifting objects can not be hoisted in swing state. 17、 请将葫芦移动到物体的正上方再起吊，，严禁歪拉斜吊。 Please move the gourd to the top of the object. 18、 限位器不允许当作行程开关反复使用。 The limiter is not allowed to be used repeatedly as a travel switch. 19、 不得起吊与地面相连的物体。 It is not allowed to lift objects that are connected to the ground. 20、 禁止过度点动操作。 Excessive action is prohibited. 21、 在使用中必须由专门人员定期对电动葫芦进行检查，发现故障及时采取措施，切断主电源，并仔细加以记录。 In the use, special personnel must be inspected regularly by special personnel to detect the failure in time to take measures to cut off the main power supply and carefully record it. 22、 在使用中必须保持足够的润滑油，并保持润滑油的干净，不应含有杂质和污垢。 It must be lubricated in use and keep the oil clean, not containing impurities and dirt. 23、 钢丝绳上油时应使用硬毛刷或木质小片，严禁直接用手给正在工作的钢丝绳上油。 The steel wire rope should be used with a hard brush or small wooden piece, and it is strictly forbidden to oil the wire rope directly. 24、 维修检查工作一定要在空载状态下进行。 The maintenance inspection must be carried out in an empty space. 25、 在维修检查前一定要切断电源。 Be sure to switch off the power supply before maintenance check. 26、 电动葫芦不工作时，不允许把重物悬于空中，防止零部件产生永久变形，造成人身财产损伤。 When the electric gourd is not working, it is not allowed to suspend the weight in the air, prevent the parts from being permanently deformed and cause damage to the person's property. 27、工作完毕后必须把电源的总闸拉开，切断电源。 When the work is finished, the main brake of the power supply must be pulled off.